Unsafe at any speed

Auto Safety Lapses Evoke the Bad Old Days

By Phil Mattera in the Dirt Diggers Digest

The Big Three carmakers, once considered the epitome of corporate irresponsibility, have been viewed in a more favorable light in recent years.

After their near-death experience of a few years back—during which two of them, General Motors and Chrysler, went bankrupt and had to be rescued by the federal government—the consensus seems to be that they have cleaned up their act. They are also being rewarded in the marketplace, where Detroit’s sales have been booming.

It is true that the Big Three are no longer exclusively focused on gas-guzzling SUVs or death traps such as the Pinto. GM is promoting its electric Volt rather than dodging Michael Moore. Yet there have been some indications recently that the giant automakers may be slipping back into old habits.

Recently, the National Highway Traffic Safety Administration finedFord Motor $17.35 million for taking too long to recall more than 400,000 SUVs that were susceptible to sudden acceleration, a problem that was linked to at least one death and nine injuries in crashes.

If you hadn’t heard about this case, it may have been because NHTSA decided not to issue a press release about the penalty. Word got out and the matter received modest coverage in a few newspapers. It was only the Corporate Crime Reporter that gave the story the prominence it deserved: front-page treatment.

The Ford penalty came a couple of months after Chrysler took the unusual step of refusing to acquiesce to NHTSA’s request that it recall 2.7 million Jeeps the agency contends are defective and prone to fires in the event of rear-impact collisions. 

Chrysler, now controlled by Italy’s Fiat, later relented but applied the recall to only 1.6 million vehicles. Moreover, its fix for the problem—installing trailer hitches on the vehicles—was dismissed as inadequate by the watchdog Center for Auto Safety, had been responsible for bringing the defect to light.

One would think that Ford, in particular, would be more diligent on safety issues, given the hard lessons of its past. This was the company, after all, that produced those ill-fated Pintos, whose unshielded fuel tanks near the back of the fragile compacts caused horrific explosions in rear-end collisions. 

Evidence later emerged that Ford was aware of the vulnerability of the gas tank, but went ahead with production of the car. In one civil case a jury awarded $125 million in damages (reduced by the judge to $3.5 million).

Ford was also embarrassed by reports that many of its cars with automatic transmissions produced during the 1970s had a tendency to slip from park into reverse. In 1981 federal regulators forced the company to send warning notices to purchasers of some 23 million vehicles about the problem. Ford may not have been happy about this, but it was a lot less onerous than the massive recall of the cars that had been urged by public interest groups.

In 1996 Ford gave in to public pressure and agreed to pay for replacing ignition switches on more than 8 million cars and trucks that were prone to short circuits that could cause fires. In 1998 State Farm, the largest auto insurer in the United States, suedFord, charging that the company withheld information about the potential fire hazard from federal regulators and the public.

In 1999 NHTSA hit Ford with a $425,000 fine in the matter. An investigation later revealed evidence that Ford knew about ignition defects, which also sometimes caused vehicles to stall out while making turns, but remained silent. A California judge then orderedthe recall of an additional two million vehicles—the first time a U.S. court had ever taken such an action against automaker.

In 2000 Bridgestone/Firestone announced a massive recall of tires, most of which had been installed on Ford sport-utility vehicles and light trucks. Ford alleged that the tire company had known of the defects for several years. Information later came out suggesting that Ford, as well as Bridgestone/Firestone, had known of the tire defects long before the recalls were announced.

An  investigation by the New York Times found that in the 1980s Ford had taken a number of design shortcuts that raised the risk of rollover accidents in what would become its wildly popular Explorer SUV.

What a track record. Let’s hope we are not returning to those bad old days of automaker recklessness.

Note: The latest addition to my CORPORATE RAP SHEETS is a dossier on Monsanto, the bully of agricultural biotechnology. Read it here.